- Open Access
Investigation and control of an outbreak of urinary tract infections caused by Burkholderia cepacian-contaminated anesthetic gel
Antimicrobial Resistance & Infection Control volume 10, Article number: 1 (2021)
This report describes an outbreak of 71 patients developed B. cepacia urinary tract infection (UTI) by contaminated single-use anesthetic gel.
Epidemiological investigation of patients with B. cepacia-positive urine or blood samples between March 19, 2018 and Novemeber 15, 2018 was conducted to identify the source of infection. Microbiological samples from hospital surfaces, endoscopes, disposable items, and the hands of staff were tested for B. cepacia contamination. Pulsed-field gel electrophoresis (PFGE) was used to compare homology in B. cepacia isolates.
During the outbreak, nosocomial B. cepacia UTI was confirmed in 71 patients. Epidemiological investigation showed that 66 patients underwent invasive urological diagnosis and treatment, while the remaining five patients underwent bedside indwelling catheterization, with all patients exposed to single-use anesthetic gel. All batches of anesthetic gel were recalled and the outbreak abated. Overall, 155 samples were collected from environmental surfaces and disposable items, and B. cepacia contamination was confirmed in samples from one used cystoscope and three anesthetic gels from the same batch. PFGE showed homology between 17 out of 20 B. cepacia isolates from patients and three isolates from the contaminated anesthetic gel. All patients achieved cure.
Contaminated single-use anesthetic gel was confirmed as the source of the B. cepacia outbreak, with infection occurring during invasive urological diagnostic and treatments. Thus, investigations of nosocomial outbreaks of B. cepacia infection should consider contamination of diagnostic and treatment items used in infected patients.
Burkholderia cepacia is a Gram-negative, aerobic, non-fermentative bacterium that is widely distributed in the hospital environment. It is also a opportunistic pathogen in immune-impaired patients with cystic fibrosis or chronic granulomatosis . In recent years, there have been frequent nosocomial outbreaks of respiratory tract, blood, and urinary tract infection (UTI) caused by B. cepacia-infected ward water sources, oral liquid, ultrasound gel, skin disinfectant, and mouthwash [2,3,4,5,6]. In 2012, Sutton and Jimenez published a summary of product recalls by the Food and Drug Administration involving microbial contamination . They showed that between 2004 and 2011, B. cepacia contamination was associated with 34% of non-sterile product recalls. In the current study, we report an outbreak of UTI among 71 patients in a tertiary general teaching hospital in China that occurred between March 2018 and November 2018. Epidemiological and microbiological investigations confirmed that the outbreak was caused by a batch of B. cepacia-contaminated single-use anesthetic gel, which was used for anesthesia and lubrication of the urethra during invasive diagnosis and treatment. The outbreak abated after the hospital stopped using the product.
The tertiary general teaching hospital where the outbreak occurred has a total of 3800 beds, with ~ 120 beds across the four inpatient wards of the Urology Surgery Department. Most urological invasive diagnoses and treatments (mainly for the examination of urinary diseases, biopsies, and minor operations) are accomplished in the outpatient cystoscope room, with about 500 cases seen per month. The outpatient cystoscope room has an adjacent room that is used for cleaning and disinfection of flexible and rigid cystoscopes.
Diagnosis of UTI was performed according to the Chinese Nosocomial Infection Diagnostic Criteria (2001) , as follows:
UTI: patients have symptoms of urinary tract irritation such as frequent urination, urination urgency, and pain on urination, or have lower abdominal tenderness, kidney area percussion pain, with or without fever, urine culture or blood culture is B. cepacia-positive. Patients also have one of the following:
Urine has ≥5 white blood cells/high power field of vision in males and ≥ 10 white blood cells/high power field of vision in females.
Diagnosed as UTI by clinician, or UTI identified by effective antibacterial treatment.
For inpatients with B. cepacia in urine or blood samples, non-nosocomial infection was defined as B. cepacia identification within 48 h of admission, while nosocomial infection was defined as B. cepacia identification later than 48 h post-admission. If infection was directly related to the last outpatient or inpatient diagnosis and treatment, the case was defined as nosocomial infection regardless of the identification time.
On August 21, 2018, doctors in the Third Ward of the Urology Department reported an upward trend in the detection of B. cepacia in the urine of patients. The B. cepacia detection data for the ward from January to August 2018 were collected, and showed 11 cases of B. cepacia infection between April 30, 2018 and August 08, 2018. In eight cases, B. cepacia was detected within 48 h of admission, indicating that the patients were infected prior to admission. The three cases of nosocomial B. cepacia infection occurred in three different months, indicating that they did not constitute an outbreak of nosocomial infection. Instead, the infections were thought to be caused by B. cepacia cross-contamination from non-nosocomial infection patients via cystoscopy or surgical treatment equipment.
On September 13, 2018, the investigation was expanded to include inpatients across the entire hospital, focusing on epidemiological investigations of patients with B. cepacia-positive urine and/or blood samples. Detailed invasive examination and operation records for both outpatients and inpatients of the Urology Department were examined. The analysis showed that most B. cepacia-positive patients were identified within 48 h of first admission, and had previously undergone invasive diagnosis and treatment in the outpatient cystoscope room of the studied hospital. As a result, 25 patients initially classified as non-nosocomial infection were revised to nosocomial infection. Data for the infected patients was re-investigated and showed that by September 30, 2018, 58 patients who met the case definition were distributed across the urology (38 cases), gynecology (10 cases), and other (10 cases) departments, and that all patients underwent invasive operations or urological examination. Importantly, only four B. cepacia-positive cases (detected in urine or blood) were recorded over the same time period in 2017. Thus, the cluster of cases was confirmed to be an outbreak.
Microbiological sampling and identification
Microbiological samples were collected from possible exposure surfaces, endoscopes, disposable items, and the hands of staff and screened for B. cepacia contamination used sterile swabs with sterile saline solution. Microbiological sampling was carried out a total of four times during the outbreak investigation. Samples included: 20 samples from cystoscopes, environmental surfaces, and the hands of doctors and nurses from the outpatient cystoscope room, collected on August 23, 2018; 70 samples from rigid and flexible cystoscopes, environmental surfaces, and the hands and clothing of staff from the Third Ward of the Urology Department. From November 11–15, 2018, the cystoscope sampling method was replaced with routine irrigation and disposable brushing, and 27 samples were collected from cystoscopes cleaned using different disinfection methods, while 20 samples were collected from disposable items (including one anesthetic lubrication gel, batch 20,170,521). A total of 18 samples were collected from all five batches of anesthesia gel and four batches of coupling agent on November 23, 2018.
All bacteria were isolated from microbiological samples according to the National Clinical Inspection Operation specifications. Species identification and in vitro antibiotic susceptibility tests were carried out using the Vitek II system (bioMérieux, Marcy-l’Étoile, France) following the 2018 breakpoints defined by the Clinical and Laboratory Standards Institute (CLSI) . Molecular typing by pulsed-field gel electrophoresis (PFGE) was performed for 24 B. cepacia isolates, including 20 isolates from nosocomial infection patients, one isolate from a non-nosocomial infection patient, and three isolates from the anesthetic gel. In addition, the B cepacia strain SperI (40 U) was used, and the Salmonella standard strain H9812 was digested with XbaI (40 U) at 37 °C for > 3 hs. The following electrophoresis conditions were used: voltage, 6 V/cm; pulse time, 5.0–50.0 s; linear conversion; conversion angle, 120°; electrophoresis time, 20 hs; and electrophoresis temperature, 14 °C. CHEF III (Bio-Rad, USA) was used for PFGE.
Different intervention measures were taken at different stages of the outbreak investigation, as follows:
Intervention A: from August 21, 2018, cleaning and disinfection of the surfaces of objects in the outpatient cystoscope room was strengthened, the hand hygiene and aseptic operation of staff was standardized, and the cleaning and disinfection of the endoscopes in the outpatient cystoscope room was supervised.
Intervention B: from September 13, 2018, the endoscopes in the outpatient cystoscope room were sent to the disinfection center each day after the last time of use, the rigid endoscope was sterilized by high temperature and high pressure, and the flexible endoscope was sterilized with ethylene oxide. Each endoscope was sterilized once per day. A manual endoscopic traceable record was established.
Intervention C: from October 26–28, 2018, the outpatient cystoscope room was closed for 3 days, and complete terminal disinfection and sterilization of all endoscopes was carried out. Each flexible endoscope was used only once per day for one patient, and then sterilized with ethylene oxide.
Intervention D: the anesthetic gel product was recalled on November 26, 2018. After this point the outbreak was terminated.
A total of 71 cases of B. cepacia nosocomial UTI were confirmed between March 19, 2018 and November 15, 2018. Among the 71 patients, there were 16 cases of B. cepacia-positive blood culture and 61 cases of B. cepacia-positive urine culture (6 cases of B. cepacia-positive blood and urine culture). The average patient age was 59 years, and 71.83% of patients were male. The time from exposure to the discovery of B. cepacia infection ranged from 0 to 65 days, with a median duration of 4 days. The majority of patients were from the urology (66.20%, 47/71) and gynecology (15.49%, 11/71) departments. The patients had a range of underlying conditions, including 47 cases of urinary tumors/stones/hydronephrosis, 11 cases of cervical cancer, and 11 cases with other illnesses accompanied by urinary disease. All of the patients required invasive diagnosis and urological treatment (examination/biopsies/placement of double-J stent, etc.) or bedside indwelling catheterization, and all equipment was lubricated with single-use anesthetic gel during intubation. Basic information on patients with B. cepacia UTI is provided in Table 1.
A total of 71 patients with B. cepacia nosocomial UTI (positive blood and/or urine culture) were confirmed in 2018, and the epidemiological curves were developed. Two cases of non-nosocomial infection with positive blood cultures and five cases of non-nosocomial infection with positive urine cultures were excluded. The first case of infection occurred during diagnostic examination of a bladder tumor in the outpatient cystoscope room on March 13. The patient developed a fever and UTI after the procedure, and B. cepacia was detected in a urine sample on March 19. After the increased incidence of B. cepacia infection was reported in the Urology Surgery Department on August 21, three intervention measures were taken to gradually upgrade the cleaning and disinfection protocols for the urology endoscopes: first, cleaning and disinfection processes were strengthened; second, each endoscope was disinfected once per day, followed by daily sterilization with ethylene oxide; third, the flexible endoscope was used only once per day and then sterilized with ethylene oxide. However, the number of patients with B. cepacia infection continued to increase, including those who underwent procedures using the flexible and rigid endoscopes. On November 26, 2018, all batches of anesthesia gel used in the hospital were recalled and the outbreak abated. No new cases of infection occurred before the end of the monitoring period (31 March, 2019). All 71 patients were cured, and no deaths related to infection were recorded. The epidemic curve for the outbreak of infection is shown in Fig. 1.
A total of 155 microbiological samples were collected across four microbiological sampling points, including 42 samples from endoscopes, 38 from disposable items, 35 from environmental surfaces, 28 from instruments, eight from the hands and clothes of staff members, and four from water. Overall, B. cepacia was only detected in one used cystoscope sample and in one batch of anesthetic gel (20180701). The bacterial load in the anesthetic gel was 104–105 colony-forming units/ml. PFGE typing showed 98–100% homology between 17 B. cepacia isolates from patients and three isolates from the contaminated gel, although slight differences were observed among the three isolates from the gel (B1, B2, and B3). One isolate from a patient infected outside the hospital (B12) and three nosocomial infected B. cepacia isolates (B10,B17,B18) were non-homologous to the isolates from the anesthetic gel. The results of PFGE typing and analysis are shown in Fig. 2.
The current study reports an outbreak of B. cepacia UTI among 71 patients that was caused by contaminated single-use anesthetic gel. The investigation lasted for 4 months, microbiological sampling and identification were repeated, careful and detailed epidemiological investigation was carried out, and various intensive endoscope disinfection and sterilization interventions were implemented; however, infection cases continued to occur. Finally, the source of infection was determined, and the outbreak abated. Our experience in identifying and eliminating the source of the outbreak may be helpful as a reference for future outbreak situations.
When the increased incidence of B. cepacia infection was first reported in the Third Ward of the Urology Department, a preliminary epidemiological investigation was carried out. Nosocomial infection was defined only as B. cepacia identification later than 48 h post-admission. Therefore we wrongly ruled some nosocomial cases out. The case was defined as nosocomial B. cepacia UTI occurring after cystoscopy in the studied hospital regardless of the identification time. This finding suggests that during an investigation of an outbreak, investigators should carefully consult the patients and communicate with the clinical staff to understand the diagnosis and treatment process before and after infection.
B. cepacia was detected in a sample from a used, unsterilized cystoscope at the beginning of the investigation. We misjudged the source of B. cepacia infection as being contamination from the infected outpatient and inadequately sanitized cystoscope, but we ignored the possibility of contaminated disposable items. As such, subsequent microbial sampling only included the disinfected endoscope, resulting in a lost opportunity to identify the source of infection in the early stages. Therefore, when an outbreak involves equipment such as an endoscope, samples should be collected not only before use and after disinfection, but also immediately after use to determine whether pathogen contamination occurred during disinfection or in the process of diagnosis and treatment.
It is also important to determine the scope of the outbreak. We originally only included patients from the urology surgery ward, before expanding the investigation to include the entire hospital. We did not examine five difficult cases (7.04%, 5/71) requiring bedside indwelling catheterization. However, if the sources of exposure of these five patients had been studied early in the investigation, we would have been able to exclude the possibility of contamination arising from improper endoscope cleaning and disinfection of the outpatient cystoscope room, which would have suggested the anesthetic gel as the source of infection.
Outbreaks of nosocomial infection caused by B. cepacia often last for weeks or years [10, 11]. It is often very difficult to determine the source of infection, and the cause of the outbreak is often unknown. However, previous reports have traced B. cepacia outbreaks back to contaminated medical items, drugs, and hospital water sources used in diagnosis and treatment, while reports of B. cepacia outbreaks caused by person-to-person infection or endoscope cleaning and disinfection failures are rare . Therefore, during nosocomial outbreaks of B. cepacia infection, investigations should focus on possible contamination of diagnosis and treatment equipment or items.
A review of the literature shows that there have been several nosocomial B. cepacia outbreaks in Europe and the United States [4, 6], but that the total number of cases in these outbreaks was small (< 20 cases). This may be because monitoring systems for nosocomial infection outbreaks have significantly improved in recent times, and infection control professionals and epidemiological experts are well equipped to investigate and control outbreaks. In addition, in the early stages of outbreak investigation, B. cepacia can be sent to regional or national joint investigation and control institutions where homology analysis or gene sequencing can be conducted quickly, and results can be compared with B. cepacia reference data in regional or national databases. The identification of identical B. cepacia strains in multiple hospitals is indicative of drug or equipment contamination, and national or regional recalls of the contaminated products can be undertaken once the source of contamination is confirmed .
However, because of the lack of monitoring and regional and/or national infection control facilities for nosocomial infections in developing countries, B. cepacia outbreaks are often only reported in one hospital. These outbreaks can last for a long time and affect many patients, meanwhile infected patients at other hospitals are very likely to be missed. All batches of anesthesia gel used in the hospital were recalled and we informed the gel manufacturer as soon as the contaminated gel confirmed. Before our incident, other hospitals also found that the infection outbreak or cluster was caused by the same reason . The national medical products administration asked the manufacturer to stop production immediately and recall all the gels. But the manufacturer forgot to notify our hospital about the recall. Otherwise, we could have avoided this outbreak Contamination of water for production was the possible source of pollution due to B cepacia during the product manufacturing process. In 2016, B. cepacia was identified in blood samples from 14 patients across three intensive care units at a hospital in Saudi Arabia. The outbreak lasted for 6 months and was traced back to the use of contaminated ultrasound gel .
We acknowledge that this study had several limitations. First, although only one batch of anesthetic gel was contaminated with B. cepacia, the five batches were mixed and batch use was not recorded. As a result, it was not possible to track the total number of patients exposed to the contaminated anesthetic gel or the total number of infected patients. Second, there was no retrospective record of endoscopic diagnosis and treatment in the outpatient cystoscope room. Thus, the incidence of infection associated with different endoscopes could not be determined, making it difficult to investigate the outbreak. Third, because of the restrict of microbial resources, only partial B. cepacia specimens could be typed by PFGE.
The internal monitoring and outbreak investigation capacity of hospitals in developing countries is insufficient, and many hospitals do not have access to technology such as microbiological homology identification. We suggest that each country should establish an effective national or regional laboratory platform for the prevention and control of infection outbreaks, allowing outbreak strains to be identified and compared against a national database. This system would help investigators to identify the source of infection and allow early intervention to terminate the outbreak.
Availability of data and materials
The datasets generated during the current study are not publicly available, to avoid disclosure of the individual privacy of the patients. However, they are available from the corresponding author on reasonable request.
urinary tract infection
pulsed-field gel electrophoresis
Mahenthiralingam E, Baldwin A, Dowson CG. Burkholderia cepacia complex bacteria: opportunistic pathogens with important natural biology. J Appl Microbiol. 2008;104:1539–51.
Rastogi N, Khurana S, Veeraraghavan B, Yesurajan Inbanathan F, Rajamani Sekar SK, Gupta D, et al. Epidemiological investigation and successful management of a Burkholderia cepacia outbreak in a neurotrauma intensive care unit. Int J Infect Dis. 2019;79:4–11.
Marquez L, Jones KN, Whaley EM, et al. An outbreak of Burkholderia cepacia complex infections associated with contaminated liquid docusate. Infect Control Hosp Epidemiol. 2017;38:567–73.
Shaban RZ, Maloney S, Gerrard J, Collignon P, Macbeth D, Cruickshank M, et al. Outbreak of health care-associated Burkholderia cenocepacia bacteremia and infection attributed to contaminated sterile gel used for central line insertion under ultrasound guidance and other procedures. Am J Infect Control. 2017;45(9):954–8.
Song JE, Kwak YG, Um TH, Cho CR, Kim S, Park IS, et al. Outbreak of Burkholderia cepacian pseudo bacteraemia caused by intrinsically contaminated commercial 0.5% chlorhexidine solution in neonatal intensive care units. J Nosocomial Infect. 2018;98:295–9.
Kutty PK, Moody B, Gullion JS, Zervos M, Ajluni M, burnR W, et al. Multistate outbreak of Burkholderia cenocepacia colonization and infection associated with the use of intrinsically contaminated alcohol-free mouthwash. Chest. 2007;132(6):1825–31.
Sutton S, Jimemez L. A review of reported recalls involving microbiological control 2004–2011 with emphasis on FDA considerations of “objectionable organisms.”. Am Pharmaceut Rev. 2012;15:42–57.
Nosocomial Infection Diagnostic Criteria (2001), National Health Commission of the People’s republic of China.
Clinical and Laboratory Standards Institute. Performance standards for antimicrobial susceptibility testing; 28th informational supplement. M100-S28. Wayne: CLSI; 2018.
Liao CH, Chang HT, Lai CC, Huang YT, Hsu MS, Liu CY, et al. Clinical characteristics and outcomes of patients with Burkholderia cepacia bacteremia in an intensive care unit. Diagn Microbiol Infect Dis. 2011;70:260–6.
Holmes A, Nolan R, Taylor R, Finley R, Riley M, Jiang R, et al. An epidemic of Burkholderia cepacia transmitted between patients with and without cystic fibrosis. J Infect Dis. 1999;179:1197–205.
Biddick R, Spilker T, Martin A, Li Puma J. Evidence of transmission of Burkholderiacepa- cia, Burkholderia multivorans, and Burkholderia dolosa among persons with cysticfibrosis. FEMS Microbiol Lett. 2003;228:57–62.
European Centres for Disease Control and Prevention. About us Sweden: European Centres for disease control and prevention; 2017. Available from: https://ecdc.europa.eu/en/about-us. Accessed 16 May 2017.
Zou Q, Li N, Liu J, Li X, Wang Z, Ai X, et al. Investigation of an outbreak of Burkholderia cepacia infection caused by drug contamination in a tertiary hospital in China. Am J Infect Control. 2020;48(2):199–203.
Abdelfattah R, Al-Jumaah S, Al-Qahtani A, Al-Thawadi S, Barron I, Al-Mofada S. Outbreak of Burkholderia cepacia bacteraemia in atertiary care Centre due to contaminated ultrasound probe gel. J Nosocomial Infect. 2018;98:289–94.
This study is funded by the National Key R&D Program of China (2017YFC0806308), and Medical Big Data Research and Development project of Chinese PLA General Hospital (2017MBD004).
Ethics approval and consent to participate
This study was approved by the studied hospital institutional review board (S2019–142-02). For this type of study, formal consent is not required.
Consent for publication
The authors declare that they have no competing interests.
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Du, M., Song, L., Wang, Y. et al. Investigation and control of an outbreak of urinary tract infections caused by Burkholderia cepacian-contaminated anesthetic gel. Antimicrob Resist Infect Control 10, 1 (2021). https://0-doi-org.brum.beds.ac.uk/10.1186/s13756-020-00855-x
- B. cepacia
- Urinary tract infection