Skip to main content

Are three antiseptic paints needed for safe preparation of the surgical field? A prospective cohort study with 239 patients

Abstract

Background

Preoperative skin antisepsis is an essential component of safe surgery. However, it is unclear how many antiseptic paints are needed to eliminate bacteria prior to incision. This study compared microbial skin counts after two and three antiseptic paints.

Methods

We conducted a prospective cohort study in non-emergency patients receiving a cardiac/abdominal surgery with standardized, preoperative skin antisepsis consisting of an alcoholic compound and either povidone iodine (PI) or chlorhexidine (CHX). We obtained three skin swabs from the participant’s thorax/abdomen using a sterile template with a 25 cm2 window: After collection of the first swab prior to skin antisepsis, and once the second and third application of PI/CHX had dried out, we obtained a second and third swab, respectively. Our primary outcome was the reduction in microbial skin counts after two and three paints of PI/CHX.

Results

Among the 239 enrolled patients, there was no significant difference in the reduction of mean square root-transformed microbial skin counts with three versus two paints (P = 0.2). But distributions of colony forming units (CFUs) decreased from paint 2 to 3 in a predefined analysis (P = 0.002). There was strong evidence of an increased proportion of patients with zero CFU after paint 3 versus paint 2 (P = 0.003). We did not identify risk factors for insufficient reduction of microbial skin counts after two paints, defined as the detection of > 5 CFUs and/or ≥ 1 pathogens.

Conclusions

In non-emergency surgical patients, three antiseptic paints may be superior to two paints in reducing microbial skin colonization prior to surgery.

Brief summary

This prospective cohort study indicated that in non-emergency surgery patients, three consecutive antiseptic paints may be superior to two antiseptic paints in reducing microbial skin counts prior to surgery.

Introduction

Surgical site infections (SSIs) are associated with increased morbidity, mortality and healthcare costs [1, 2]. Most SSIs after elective surgery may relate to residual, viable bacteria at the surgical site; therefore, preoperative skin antisepsis is a cornerstone of SSI prevention, coupled with routine antimicrobial prophylaxis to avoid regrowth of residual bacteria [3,4,5]. However, skin antisepsis practices are heterogeneous across different healthcare institutions and countries. Although the antimicrobial effectiveness of preoperative surgical site preparations may depend on both the antiseptic agent used and its specific application method, it is still unclear how many antiseptic paints are needed to adequately reduce microbial skin colonization at the surgical site: As of yet, no international, evidence-based recommendations exist on this topic, and experimental standards to compare and license preoperative application techniques for skin antisepsis are not established [6, 7].

We therefore aimed to compare the effectiveness of two versus three antiseptic paints in reducing the microbial skin colonization at the surgical site. We hypothesized that three preoperative paints with either chlorhexidine (CHX) or povidone iodine (PI) are superior to two paints in reducing microbial skin counts.

Methods

Study design and setting

We performed a prospective cohort study at the University Hospital Basel (USB) ─ a tertiary care center in Switzerland with > 1700 abdominal and > 850 cardiac interventions per year (overall, ~ 38,000 surgical interventions per year). The present observational study was nested within an ongoing multicenter open-label cluster-randomized cross-over study on the efficacy of CHX versus PI skin antisepsis in preventing SSIs (i.e. PICASSo trial; ClinicalTrials.gov numbers, NCT03685604 and NCT03859375). The study data can be shared by the corresponding author upon request.

Patient selection

At the USB, inpatients aged ≥18 years receiving a non-emergency cardiac or abdominal surgery between April 15, 2019 and September 06, 2019 were eligible for study inclusion. We excluded patients who could not provide or declined the written informed consent for the nested study. The PICASSo trial protocol does not include an individual informed consent.

Study outcomes

Our predefined primary outcome was the reduction of microbial skin counts (that is, colony forming units [CFUs]) after two and three antiseptic paints, respectively. Secondary outcomes were (i) the proportion of patients with microbial skin counts of zero CFU after three antiseptic paints as compared to two antiseptic paints, and (ii) the proportion of patients with insufficient reduction of microbial skin counts after two antiseptic paints. We defined an insufficient reduction in microbial skin counts at the surgical site as the detection of > 5 CFUs and/or ≥ 1 pathogen(s) according to the National Healthcare Safety Network common commensals/pathogen list (version 9.2; www.cdc.gov). All outcomes were standardized per 25 cm2 skin area.

In a secondary analysis, we merged the prospectively collected SSI status within 30 days after surgery using a national SSI surveillance database [8, 9]. In this validated surveillance program, well-trained infection control practitioners ascertain SSIs by screening surgical patients for evidence of SSIs, and cases are double-checked by a board-certified infectious disease specialist. Standardized postdischarge SSI surveillance is conducted by telephone interviews and review of electronic medical records. SSIs are classified according to the Centers for Disease Control and Prevention definitions [10].

Study procedures

Patients routinely receive a whole body shower with CHX (CHX digluconate 40 mg/ml solution; Hibiscrub®, Mölnlycke Health Care AG, Schlieren, Switzerland) prior to cardiac or abdominal surgery. Furthermore, it is standard practice to clip hair prior to surgery ─ if deemed necessary. Presurgical antiseptic processes and management are in accordance with the recommendations of the World Health Organization (WHO) [4]. At the USB, it is standard of care to consecutively perform skin antisepsis for three times (approximately 3 min at a time) by using sterile gauzes. The routinely applied skin antiseptics are either CHX in alcohol (CHX digluconate 20 mg and propan-2-ol 0.7 ml; Softasept® CHX, B. Braun Medical AG, Sempach, Switzerland) or PI in alcohol (PI 0.9 mg and propan-2-ol 457.5 mg; Braunoderm®, B. Braun Medical AG, Sempach, Switzerland). The PICASSo trial did not affect the routine procedures for skin antisepsis as recommended by the WHO [4], apart from the regular randomized department-level switches from presurgical skin antisepsis with PI to CHX, or vice versa.

For the present study, well-instructed members of the surgical team obtained the skin swabs in the operating room under sterile conditions. We collected three skin swabs (sterile 0.9% sodium chloride premoistened swabs; FLOQSwab®, Copan Diagnostics Inc., Brescia, Italy) from the participant’s trunk. To standardize the skin area, we used sterilized metal templates with a window of 25 cm2, which was swabbed repeatedly horizontally and vertically in a uniform way under gentle pressure. The template was freely positionable at the surgical site (thorax or abdomen) as long as it did not interfere with the succeeding incision. Following collection of the first skin swab prior to skin antisepsis, and once the second and third application of PI or CHX had dried out, we obtained a second and third skin swab, respectively. We did not collect swab samples at later time points, as the surgical incision may follow directly after the drying of the third application of PI or CHX (that is, start of the at-risk period).

The first skin swab was neutralized for CHX to avoid bias by presurgical shower with CHX. Swabs 2 and 3 were neutralized before culture for either CHX or PI ─ depending on the applied antiseptic product. We used a standardized inactivation solution, which was tested for non-toxicity and which was microbiologically validated ─ containing either polysorbate 80 30 g/l, lecithin 3 g/l, L-histidine 1 g/l, sodium thiosulfate 5 g/l, saponine 30 g/l, trypticase soy broth 30 g/l, and distilled water 1 l for CHX skin antisepsis; or polysorbate 80 30 g/l, lecithin 3 g/l, L-histidine 1 g/l, sodium thiosulfate 5 g/l, trypticase soy broth 30 g/l, and distilled water 1 l for PI skin antisepsis (details can be requested from the corresponding author).

Data collection

A study physician collected the relevant clinical information during the screening visit and verified the respective data by use of electronic medical records. In the operation room, a trained study nurse recorded the applied antiseptic product and timing of skin swab collection.

Microbiological investigation

Skin swabs were immediately delivered to the in-house microbiological laboratory, where a study technician inoculated trypticase soy agar (TSA) plates (bioMérieux, Marcy l’Etoile, France) within 6 h during weekdays or within 72 h on weekends (samples were kept in the refrigerator before processing). Due to logistical reasons, we could not mask the study technician for the exposure status (that is, consecutive paint number; 1 to 3). We cultured an additional 1:10 sodium chloride diluted sample of the first swab to safeguard against unreliable results for samples with high microbial counts. We incubated the TSA plates for 2 days at 36 °C (±1 °C) and determined respective CFUs with a manual colony counter (Scan® 100, Intersciences, Saint Nom, France). We identified microbial skin isolates using the microflex™ LT MALDI-TOF mass-spectrometer system (Bruker Daltonics, Bremen, Germany).

Statistics

Based on a previous internal quality evaluation (unpublished data), we estimated a sample size of ≥228 patients in order to demonstrate superiority of three versus two paints at a clinically defined superiority margin of 2 log10(CFUs) difference (significance level of 5%, power of 90%). Our null hypothesis was that there was no difference between two and three paints of PI/CHX in reducing microbial skin counts (CFUs) at the surgical site.

With regards to the primary outcome, we compared the square root-transformed CFUs after paint 2 and 3 using a paired t-test. In a supplementary analysis of the primary outcome, we also compared the CFU distribution after paints 2 and 3 using the Wilcoxon signed rank test. We compared secondary outcomes (proportions) after paint 2 and 3 using a χ2-test (overall and stratified by PI/CHX application). In a secondary analysis, we compared CFU counts after paint 3 between patients with and without a subsequent SSI (within 30 days after index surgery) using the Wilcoxon rank sum test.

We fitted univariable logistic regression models (variables and categories provided in Table 3) to identify potential risk factors for insufficient reduction of microbial skin counts after paint 2. A low event-predictor ratio precluded a multivariable logistic regressions analysis. Results were considered significant at a P-value of ≤0.05. Analyses of secondary outcomes and subgroups were considered as hypothesis-generating. The study data were analyzed by a statistician (A.A.) using the R statistical software (www.r-project.org).

Results

During the study period, we included 239 of 334 (71.6%) screened patients who received a non-emergency cardiac or abdominal surgery (Fig. 1); we excluded the remaining 95 screened patients due to logistic reasons or refused/withdrawn informed consents.

Fig. 1
figure 1

Patient Selection

Overall, the median age of the study population was 65.0 years (interquartile range [IQR], 56.5 to 72.5 years) and 231 of 239 patients (96.7%) received an adequate antimicrobial prophylaxis (Table 1). Due to ongoing cluster randomization, 94 and 145 of 239 patients (39.3 and 60.7%) received preoperative skin antisepsis with CHX and PI, respectively. The median overall PI/CHX exposure time was 7.6 min (IQR, 6.5 to 9.0 min). Fifteen of 239 (6.3%) patients developed an SSI within 30 days after surgery.

Table 1 Baseline characteristics of patients undergoing a non-emergency cardiac or abdominal surgery (n = 239 patients)

Regarding the primary outcome, there was overall no statistically different reduction in square root-transformed microbial skin counts with three versus two paints (P = 0.2; Table 2); but there was strong evidence in a supplementary analysis that the respective CFU distributions were different for paint 2 and 3 (P = 0.002): This difference could also be observed in the PI subgroup but not in the CHX subgroup. Median CFUs after paint 2 and 3 were 0.0 (IQR, 0.0 to 0.0) in the overall study population and the PI and CHX subgroups, respectively. For illustration purposes, we depict the overall and PI/CHX-stratified CFU counts in Fig. 2.

Table 2 Microbial skin counts prior to and during preoperative skin antisepsis
Fig. 2
figure 2

Microbial skin counts; overall and stratified by antiseptic product. CFU, colony forming units; CHD, chlorhexidine; PI, povidone iodine. Note: Among the 239 individuals, CFU data were missing for 1 patient at baseline, for 3 patients after paint 2, and for 2 patients after paint 3. Regarding the log-transformed CFU values, boxes cover the median and 25 to 75% percentiles. CFU counts were increased by a very small fraction to avoid zero values

Concerning the secondary outcomes, there was overall strong evidence of an increased proportion of patients with zero CFU after paint 3 versus 2 (94.5% versus 86.0%, P = 0.003; Table 2): This difference could be observed correspondingly in the PI subgroup but not in the CHX subgroup. The overall proportion of patients with insufficient reduction after paint 2 and 3 was similar (Table 2), but we were unable to identify risk factors for insufficient microbial reduction after two paints of PI/CHX (Table 3). Following paint 2, we isolated a pathogen in one of the 239 patient (that is, Staphylococcus aureus); after paint 3, no pathogens were detected in any of the 239 studied patients. In a secondary analysis, median CFU counts after paint 3 were similar for patients with and without subsequent SSI within 30 days after surgery (median CFU count, 0; IQR, 0 to 0; and median CFU count 0; IQR, 0 to 0; P = 0.8).

Table 3 Risk factors for insufficient reduction of microbial skin counts after two paints of preoperative skin antisepsis

Discussion

In contrast to hand hygiene and other infection prevention measures, evaluations of preoperative techniques for skin antisepsis might be considered a neglected research area ─ despite its potential impact on morbidity, mortality, logistics and healthcare costs [6, 7, 11,12,13]. In the present prospective cohort study performed in non-emergency patients receiving a cardiac or abdominal surgery, we observed overall similar square root-transformed microbial skin counts after two and three applications of PI or CHX. In a supplementary analysis on untransformed microbial skin counts, there was evidence, however, of different CFU distributions after three versus two paints ─ in both the overall study population and the PI subgroup. Furthermore, there was overall strong evidence of an increased proportion of patient with zero CFU after paint 3 versus 2. To our knowledge, this is the first clinical study that compared the antimicrobial effectiveness of different numbers of PI/CHX applications for preoperative skin antisepsis.

The somewhat conflicting results of our primary and supplementary analysis may be explained by the different nature of the two test procedures (comparison of mean CFUs and the shape of CFU distributions, respectively) with the former test statistic requiring approximately equal variance between groups: This was not the case in our sample, even with appropriate data transformations. In the PI and CHX subgroup, the observed differential effect in the reduction of microbial skin counts after paint 2 and 3 (Table 2) could be related to an improved antimicrobial effectiveness of CHX [4, 5]. As we had collected CHX-inactivated microbial skin swabs directly after paint 2 and 3, it seems unlikely that prolonged antimicrobial effects of CHX resulted in the observed differential effect.

Interestingly, we did not identify potential risk factors for insufficient microbial reduction after two paints of CHX or PI (Table 3). This may indicate that unmeasured variables and/or non-estimable associations in strata without cases (e.g. patients who received adequate antimicrobial prophylaxis) may contribute to a differential reduction in microbial skin counts after two paints of CHX or PI. Currently, this observation may preclude application of only two antiseptic paints in possible low-risk surgical subgroups.

Our study has strengths. Firstly, we conducted an adequately powered prospective cohort study with consecutive PI/CHX inactivation of swab samples using validated inactivation solutions: Previous studies assessing the antimicrobial effectiveness of different skin antiseptics may have frequently been based on swab samples, which were not PI/CHX inactivated: This could lead to outcome misclassification. Secondly, we chose a pragmatic study approach that may depict the antimicrobial effectiveness of skin antisepsis techniques under real-world conditions. Thirdly, our study was conducted by a well-instructed study team limiting the potential for information bias.

Nonetheless, our study has limitations. Firstly, our study was not powered to detect differences in the antimicrobial effectiveness (swab 2 versus 3) for the given subgroups. These stratified analyses should be considered as hypothesis-generating only. Secondly, due to logistical reasons, we could not mask our study technician for the exposure status (that is, paint number). However, it is highly unlikely that the known exposure status has led to systematic errors when counting microbial skin counts. Thirdly, we cannot exclude the possibility that exclusions of patients due to refused informed consents and logistical reasons may have resulted in selection bias. Nevertheless, it is unlikely that excluded patients would show differential antimicrobial effects after two versus three paints, as reasons for exclusion were manifold and probably not related to the propensity for inadequate microbial reduction. As we analyzed intra-subject differences in microbial skin counts, we have accounted for static confounders in the paint number-CFU relationship. Fourthly, our sample size and the institution-wide recommendation to apply three preoperative antiseptic paints precluded the investigation of the paint number-SSI relationship. Lastly, our study was performed in non-emergency surgical patients under a study setting ─ potentially leading to a Hawthorne effect: Our results may not be generalizable to other surgical populations and settings.

Conclusion

In non-emergency surgical patients, three consecutive antiseptic paints may be superior to two paints in reducing microbial skin colonization prior to surgery. Our observational findings warrant further evaluation in a randomized trial to better characterize the clinical efficacy and effectiveness of different skin antisepsis methods. Evidence-based standards on preoperative techniques for skin antisepsis are needed.

Availability of data and materials

Not applicable.

Abbreviations

BMI:

Body mass index

CI:

Confidence interval

CFU:

Colony forming unit

CHX:

Chlorhexidine

IQR:

Interquartile range

OR:

Odds ratio

PI:

Povidone iodine

SD:

Standard deviation

SSI:

Surgical site infection

TSA:

Trypticase soy agar

USB:

University Hospital Basel

References

  1. Zimlichman E, Henderson D, Tamir O, et al. Health care-associated infections: a meta-analysis of costs and financial impact on the US health care system. JAMA Intern Med. 2013;173(22):2039–46.

    Article  Google Scholar 

  2. Cassini A, Plachouras D, Eckmanns T, et al. Burden of six healthcare-associated infections on European population health: estimating incidence-based disability-adjusted life years through a population prevalence-based modelling study. PLoS Med. 2016;13(10):e1002150.

    Article  Google Scholar 

  3. Koek MBG, Hopmans TEM, Soetens LC, et al. Adhering to a national surgical care bundle reduces the risk of surgical site infections. PLoS One. 2017;12(9):e0184200.

    Article  Google Scholar 

  4. Allegranzi B, Zayed B, Bischoff P, et al. New WHO recommendations on intraoperative and postoperative measures for surgical site infection prevention: an evidence-based global perspective. Lancet Infect Dis. 2016;16(12):e288–303.

    Article  Google Scholar 

  5. Berrios-Torres SI, Umscheid CA, Bratzler DW, et al. Centers for Disease Control and Prevention guideline for the prevention of surgical site infection, 2017. JAMA Surg. 2017;152(8):784–91.

    Article  Google Scholar 

  6. Kamel C, McGahan L, Polisena J, Mierzwinski-Urban M, Embil JM. Preoperative skin antiseptic preparations for preventing surgical site infections: a systematic review. Infect Control Hosp Epidemiol. 2012;33(6):608–17.

    Article  Google Scholar 

  7. Sidhwa F, Itani KM. Skin preparation before surgery: options and evidence. Surg Infect. 2015;16(1):14–23.

    Article  Google Scholar 

  8. Troillet N, Aghayev E, Eisenring MC, Widmer AF. Swissnoso. First results of the Swiss National Surgical Site Infection Surveillance Program: who seeks shall find. Infect Control Hosp Epidemiol. 2017;38(6):697–704.

    Article  Google Scholar 

  9. Roth JA, Juchler F, Dangel M, Eckstein FS, Battegay M, Widmer AF. Frequent door openings during cardiac surgery are associated with increased risk for surgical site infection: a prospective observational study. Clin Infect Dis. 2019;69(2):290–4.

    Article  Google Scholar 

  10. Horan TC, Gaynes RP, Martone WJ, Jarvis WR, Emori TG. CDC definitions of nosocomial surgical site infections, 1992: a modification of CDC definitions of surgical wound infections. Infect Control Hosp Epidemiol. 1992;13(10):606–8.

    Article  CAS  Google Scholar 

  11. Tschudin-Sutter S, Frei R, Egli-Gany D, et al. No risk of surgical site infections from residual bacteria after disinfection with povidone-iodine-alcohol in 1014 cases: a prospective observational study. Ann Surg. 2012;255(3):565–9.

    Article  Google Scholar 

  12. Widmer AF, Rotter M, Voss A, et al. Surgical hand preparation: state-of-the-art. J Hosp Infect. 2010;74(2):112–22.

    Article  CAS  Google Scholar 

  13. Tschudin-Sutter S, Rotter ML, Frei R, et al. Simplifying the WHO 'how to hand rub' technique: three steps are as effective as six-results from an experimental randomized crossover trial. Clin Microbiol Infect. 2017;23(6):409e1–4.

    Article  Google Scholar 

Download references

Acknowledgments

We thank Alexander Schweiger, Danica Nogarth, Janine Voegele, Claudia Hornung, Mechthild Burbach, and Barbara Ligresti ─ all from the University Hospital Basel, Basel, Switzerland ─ for their valuable help with the present study.

Funding

This work was supported by the Swiss National Science Foundation (SNSF), Switzerland, as part of a multicenter cluster-randomized cross-over trial [grant number SNF33IC30_173534].

Author information

Authors and Affiliations

Authors

Contributions

Designed the study: Andreas Widmer and Jan Roth. Analyzed the data: Andrew Atkinson. Wrote the first manuscript draft: all authors. Final decision to submit the article: all authors. The author(s) read and approved the final manuscript.

Author’s information

Not applicable.

Corresponding authors

Correspondence to Jan A. Roth or Andreas F. Widmer.

Ethics declarations

Ethics approval and consent to participate

The Ethics Committee of Northwestern and Central Switzerland approved this nested study project (No. 2018–02292). All participants provided a written informed consent.

Consent for publication

The authors have given their consent for publication.

Competing interests

None.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Roth, J.A., Schwab, C., Atkinson, A. et al. Are three antiseptic paints needed for safe preparation of the surgical field? A prospective cohort study with 239 patients. Antimicrob Resist Infect Control 9, 120 (2020). https://0-doi-org.brum.beds.ac.uk/10.1186/s13756-020-00780-z

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/s13756-020-00780-z

Keywords